Indian Journal of Geo-Marine Sciences

Open Access Open Access  Restricted Access Subscription Access

Production of Biodiesel from Marine Green Seaweed Using a Renewable Low-Cost Heterogeneous Catalyst


Affiliations
1 Sathyabama Institute of Science and Technology, Chennai – 600 119, India
2 Department of Chemical Engineering, Sathyabama Institute of Science and Technology, Chennai – 600 119, India
3 Department of Aeronautical Engineering, Sathyabama Institute of Science and Technology, Chennai – 600 119, India
 

In this study, the biodiesel produced from Ulva lactuca, a marine green seaweed by solid oxide catalyst derived from low-cost waste eggshells is evaluated. Waste eggshells were calcined at 500 °C, 600 °C and 700 °C to increase catalytic activity which was characterized by X-ray diffraction pattern. The peaks of CaO were obtained by calcinations carried out at 700 °C for varied time periods. Comparison of images of scanning electron microscope of calcined eggshells with natural eggshells showed the formation of porous structure with an average pore diameter of 39.17 nm. Biodiesel was prepared by transesterification of algal oil by uncalcined eggshells, calcined eggshells and commercial calcium oxide with methanol. The yield of biodiesel was higher for calcined eggshells (78 %) than uncalcined eggshells (53 %). The produced biodiesel was sampled and analyzed for Gas chromatography – mass spectrometry, which confirmed the presence of predominant alkyl esters like hexadecenoic acid methyl ester, docosanoic methyl ester, palmitic acid methyl ester and oleic acid methyl ester. The heterogeneous catalyst can be reused upto seven times without any prescribed loss of catalyst activity. The Introduction of this eco-friendly catalyst in the transesterification reaction of biodiesel from Ulva lactuca will be cost-reduction for the production of an alternative green fuel.

Keywords

Algal Biodiesel, Eggshell, Green Seaweed, Heat Treatment, Metal Oxide Catalyst.
User
Notifications
Font Size

  • Ma F & Hanna M A, Biodiesel production: A review, Biores Technol, 70 (1999) 1–15.

  • Norzita N, Nur Fadzlyana H, Onn H & Ramadhansyah P J, Production of biodiesel from palm oil using eggshell waste as heterogeneous catalyst, J Teknologi, 78 (2016) 59-63.

  • El-Gendy N S & Deriase S F, Waste eggshells for production of biodiesel from different types of waste cooking oil as waste recycling and a renewable energy process, Energy Sour A: Recovery, Util Environ Eff, 37 (2015) 1114–1124.

  • Niju S, Meera K M, Begum S & Anantharaman N, Modification of eggshell and its application in biodiesel production, J Saudi Chem Society, 18 (2014) 702–706.

  • Ziku W, Chunli X & Baoxin L, Application of waste eggshell as low-cost solid catalyst for biodiesel production, Biores Technol, 100 (2009) 2883–2885.

  • Viriya-empiku N, Krasae P, Puttasawat B, Yoosuk B, Chollacoop N & Faungnawakij K, Waste shells of mollusk and egg as biodiesel production catalysts, Biores Technol, 101 (2010) 3765–3767.

  • Khemthong P, Luadthong C, Nualpaeng W, Changsuwan P, Tongprem P, et al., Industrial eggshell wastes as the heterogeneous catalysts for microwave-assisted biodiesel production, Cat Today, 190 (2012) 112– 116.

  • Yie H T, Mohammad O A, Cirilo N H & Yun H T Y, Waste ostrich- and chicken-eggshells as heterogeneous base catalyst for biodiesel production from used cooking oil: Catalyst characterization and biodiesel yield performance, Appl Energy, 160 (2015) 58–70.

  • Joshi G, Rawat D S, Lamba B Y, Bisht K K, Kumar P, et al., Transesterification of Jatropha and Karanja oils by using waste eggshell derived calcium based mixed metal oxides, Energy Convers Manage, 96 (2015) 258–267.

  • Ngoya T, Funmilayo A E & Oluwaseun O, Optimization of biodiesel production from waste vegetable oil and eggshell ash, South Afr J Chem Eng, 23 (2017) 145-156.

  • Kawashima A, Matsubara K & Honda, Acceleration of catalytic activity of calcium oxide for biodiesel production, Biores Technol, 100 (2009) 696–700.

  • Sarin R, Arora A K, Puri S K, Prakash S, Ranjan R, et al., Novel catalyst composition for biodiesel production and a process for producing biodiesel and product thereof, U.S. Patent, (Appl. No. 1348IN033), 2009.

  • Vasudevan P T & Briggs M, Biodiesel production-current state of the art and challenges, J Ind Microb Biotech, 35 (2008) 421–430.

  • Atadashi I M, Aroua M K, Abdul Aziz A R & Sulaiman N M N, The effects of catalysts in biodiesel production-a revie, J Ind Eng Chem, 19 (2013) 14–26.

  • Ahmed A S, Khan S, Hamdan S, Rahman R, Kalam A, et al., Biodiesel Production from macro algae as a green fuel for diesel engine, J Energy Environ, 2 (2010) 1-5.

  • Bradley W D, Michael M R, Alex M T, Robert W M, Michael M D, et al., Biodiesel from microalgae, yeast, and bacteria: Engine performance and exhaust emissions, Energy Fuels, 27 (2013)

  • Velappan R, Sivaprakasam S & Kannan M, Study on the Performance of Algae Oil in Diesel Engine with various injection pressure, IJRET, 2 (2015) 1152-1157.

  • Farouk E-B K, Gadb M S, Sayeda M, Abdoc K A, Abedd I, et al., A performance and exhaust emission of a diesel engine burning algal biodiesel blends, IJMME, 16 (2015) 151 – 158.

  • Gokhan T & Kadir A, Evaluation of methyl ester of microalgae oil as fuel in a diesel engine, Fuel, 112 (2013) 203–207.

  • John K M, Wen-Jhy L, Liang-Ming W, Tser Son W, Wei-Hsin C, et al., Microalgae oil: Algae cultivation and harvest, algae residue torrefaction and diesel engine emissions tests, Aerosol Air Qual Res, 15 (2015) 81–98.

  • Niraj S, Toparel V C, Renge S, Khedkar Y P, Chavan, et al., Biodiesel from algae oil as an alternative fuel for diesel engine, Int J Chem, Environ Pharm Res, 2 (2011) 116-120.

  • Annam R A, Paul C P, Parveen S, Prayashi P & Azmin H, Utilization of waste eggshells for production of renewable catalyst for transesterification, Int J Pharm Pharmaceut Sci, 8 (2016) 1-4.

  • Jutika B, Dhanapati D & Ashim Thakur J, A review on solid oxide derived from waste shells as catalyst for biodiesel production, Renew Sustain Energy Revs, 16 (2012) 904– 910.

  • Annam R A, Nurshaun S & Magesh P D, Optimization of algal methyl esters using RSM and evaluation of biodiesel storage characteristics, Biores Bioproc, (2014) 1-19.

  • Freedman B, Pryde E H & Mounts T L, Variables affecting the yields of fatty esters from transestrified vegetable oils, JAOCS, 61 (1984) 1638-1643.

  • Feuge R O & Grose T, Modification of vegetable oils. VII. Alkali catalyzed interesterification of peanut oil with ethanol, JAOCS, 26 (194) 97-102.

  • Tanaka Y, Okabe A & Ando S, Method for the preparation of a lower alkyl ester of fatty acids,, US Patent, 4 (1981) 303-590.

  • Guan-Yi C, Rui S, Jia-Fu S & Bei-Bei Y, Transesterification of palm oil to biodiesel using rice husk ash-based catalysts, Fuel Proces Tech, 133 (2015) 8-13.

  • Yelda H B, Green Biodiesel Synthesis Using Waste Shells as Sustainable Catalysts with Camelina sativa oil, J Chem, 6715232 (2016) 1-10.

  • Sharma Y C, Bhaskar S & John K, Application of an efficient nonconventional heterogeneous catalyst for biodiesel synthesis from Pongamia pinnata oil, Energy Fuels, 24 (5) (2010) 3223–3231.

  • Roland A L & Jean M L, From first to third generation biofuels: Challenges of producing a commodity from biomass of increasing complexity, Animal Front, 3 (2013) 6-11.

  • Boonyawan Y, Parncheewa U & Buppa S, Hydration-Dehydration Technique: From Low cost Material to Highly active Catalyst for biodiesel production, In: Material challenges and testing for manufacturing, mobility Biomedical application and climate, (Springer), 840 (2014) 170-188.

  • Kumar H, Renita A A & Anderson A, Response surface optimization for biodiesel production from waste cooking oil utilizing eggshell as heterogeneous catalyst, Mat Today: Proc, 47 (4) (2021) 1054-1058.


Abstract Views: 141

PDF Views: 94




  • Production of Biodiesel from Marine Green Seaweed Using a Renewable Low-Cost Heterogeneous Catalyst

Abstract Views: 141  |  PDF Views: 94

Authors

H. Kumar
Sathyabama Institute of Science and Technology, Chennai – 600 119, India
A. Annam Renita
Department of Chemical Engineering, Sathyabama Institute of Science and Technology, Chennai – 600 119, India
A. Anderson
Department of Aeronautical Engineering, Sathyabama Institute of Science and Technology, Chennai – 600 119, India

Abstract


In this study, the biodiesel produced from Ulva lactuca, a marine green seaweed by solid oxide catalyst derived from low-cost waste eggshells is evaluated. Waste eggshells were calcined at 500 °C, 600 °C and 700 °C to increase catalytic activity which was characterized by X-ray diffraction pattern. The peaks of CaO were obtained by calcinations carried out at 700 °C for varied time periods. Comparison of images of scanning electron microscope of calcined eggshells with natural eggshells showed the formation of porous structure with an average pore diameter of 39.17 nm. Biodiesel was prepared by transesterification of algal oil by uncalcined eggshells, calcined eggshells and commercial calcium oxide with methanol. The yield of biodiesel was higher for calcined eggshells (78 %) than uncalcined eggshells (53 %). The produced biodiesel was sampled and analyzed for Gas chromatography – mass spectrometry, which confirmed the presence of predominant alkyl esters like hexadecenoic acid methyl ester, docosanoic methyl ester, palmitic acid methyl ester and oleic acid methyl ester. The heterogeneous catalyst can be reused upto seven times without any prescribed loss of catalyst activity. The Introduction of this eco-friendly catalyst in the transesterification reaction of biodiesel from Ulva lactuca will be cost-reduction for the production of an alternative green fuel.

Keywords


Algal Biodiesel, Eggshell, Green Seaweed, Heat Treatment, Metal Oxide Catalyst.

References