Open Access
Subscription Access
Open Access
Subscription Access
Design of a Hybrid Solar/Gas Turbine Power System for Beta Glass Plc, Delta Plant
Subscribe/Renew Journal
Design of a Hybrid Solar/Gas Turbine power system was carried out for Beta Glass Delta Plant, a company that uses solely gas turbine to power their production floor. This project is to reduce overall running cost to power the production floor taking into account the high cost of fueling the gas turbine, its repair and maintenance. To achieve this, the load profile for the production floor was gotten, the gas usage by the gas turbine and the cost was gotten, the equivalent sunlight hour for the region was gotten and the Solar Panels together with the inverters needed to carry the load was calculated and designed. It was discovered that the watt hour from each generating unit of the Hybrid system reduced by half as compared to using solely gas turbine as power source to the production floor. These data where entered in RETScreen software for simulation. The hybrid system design shows that fifty percent (50%) of our energy is been saved daily as against using solely gas turbine. Green House Gas (GHG) was found reduced and the financial analysis shows that the cash inflow increases exponentially. This proves to be more cost effective as substantial amount would be saved on monthly bases from gas usage and this will also increase the working life of the gas turbine as its rate of usage has been reduced by twelve (12) hours daily.
Keywords
- www.siemen.com
- Sylvian Quoilin, Sustainable Energy conversion through the use of Organic Rankine Cycles for waste heat recovery and solar applications, PhD Thesis, Univeristy of Liege, Belgium, 2011.
- NASA,https://eosweb.larc.nasa.gov/cgibin/sse/grid.cgi?&num=186096&lat=5.5&hgt=100&submit=Submit&veg=17&sitelev=&email=&p=grid_id&p=avg_kt&p=mx_horizon&step=2&lon=5.983, December 15th, 2015
- Ojo, O., Fundamentals of physical and dynamic climatology. 1st edition, SEDEC Publ., Lagos, Nigeria 2000
- Falade, T. S., Solving housing problems in Lokoja, B.Sc. Research Report. Department of Architecture, A.B.U. Zaria, 1995.
- Ani, V.A. and Emetu, A. N., Simulation and optimization of hybrid diesel power generation system for GSM base station site in Nigeria, Electronic Journal of Energy & Environment, 2013, vol. 1, no 1. In Press.
- Hoque M.M, I.K.A Bhuiyan, Rajib Ahmed, A.A .Farooque & S.K Aditya, Design, Analysis and Performance Study of a Hybrid PVDiesel - Wind System for a Village Gopal Nagar in Comilla, Global Journal of Science Frontier Research Physics and Space Sciences Volume 12, Issue 5, Version 1.0, 2012.
- Faruk, N., Ayeni, A. A., Muhammad, M. Y., Abdulkarim, A. and Moses O., Hybrid power systems for cell sites in mobile cellular networks, Cy-ber Journals: Multidisciplinary Journals in Science and Technology, Journal of Selected Areas in Renewable and Sustainable Energy (JRSE), 2012, January Edition.
- Kenneth E. Okedu and Roland Uhunmwangho, Renewable energy in Nigeria: The Challenges and opportunities in mountainous and riverine region, International Journal of Renewable Energy Research, IJRER, 2015, Vol. 5, No 1.
- Wibberley L, P. Scaife, J. Winsen, GHG and Cost Implications of Spinning Reserve for High-Penetration Renewables, Technology Assessment Report 7, Australian Cooperative Research Centre for Coal, Pullenvale, 2008.
- Saheb-Koussa, D. “Economic and technical study of a hybrid system (wind-photovoltaic-diesel) for rural electrification in Algeria”. Applied Energy, pp 1024-1030, 2009.
- Al-Asadi S. Q. and Kazem H. A. “Feasibility Study of Photovoltaic/Wind/Battery Hybrid System for Oman”, IRACST, 2013, Vol. 3, No.3, pp 466-470.
- Boehm R., (Design Analysis of Thermal Systems, John Wiley & Sons, New Jersey, 1987.
- Borel L., D. Favrat, Thermodynamique et Energétique I, de l’Energie à l’Exergie, Presses Polytechniques et Universitaires Romandes, Lausanne, 2004.
- Oko, C. O. C., Engineering Thermodynamics, An algorithmic approach, University of Port Harcourt press, 2012, pp429.
- Wilson D., The Design of High Efficiency Turbo machinery and Gas Turbines, The MIT Press, Cambridge, 1984.
- Bhargava R., M. Bianchi, A. De Pascale, Gas Turbine Based Power Cycles - A State-of-the-Art Review, Proceedings of the Power Engineering Conference, Hangzhou, 2007.
- Siemens Industrial Turbomachinery, Industrial Gas Turbines: The Comprehensive Product Range from 5 to 50 Megawatts, Siemens AG, Energy Sector, Erlangen, 2012.
- James D. Spelling, Hybrid Solar Gas-Turbine Power Plant, A Thermoeconomic Analysis, PhD Thesis, 2013.
- http://en.wikipedia.org/wiki/Solar_core, June 2nd, 2015.
- Quadrelli, R. and Peterson, S. The Energy-climate challenge: Recent trends in CO2 emissions from fuel combustion, Energy Policy 35(11), pp5938-5952, 2007.
- Frick, S. (2009), Design Approach for geothermal binary power plants, Low-bin project. At www.lowbin.eu/documentation.php.
- Twaha, S., Idris, M. H., Anwari, M., and Khairuddin, A. Applying grid connected PV system as alternative source of electricity to supplement hydro power instead of using diesel in Uganda, Energy Vol. 37, No 1, pp. 185-194, (2012).
- Kamalupur, G. D and Udaykumar R. Y. Rural electricifationin India and feasisibility of PV home systems, International Journal of Electrical Power and Amp, Energy System, Vol. 33, No.3, pp. 594-599. (2011) [25] Bala, E. J.; Ojosu, J. O. and Umar, I.H. Government policies and programmes on the development of solar-PV sub-sector in Nigeria. Nigerian Journal of Renewable Energy, 2000, vol. 8, no 1&2, pp1-6.
- Daniel F. Butay, Maximum Peak Power Tracker, A Solar Application, Worcester Polytechnic institute, 2008.
- Rakesh, S., Balaram, D., Rati R. S., Manoj, K. S., Hybrid Power Model of Renewable Energy Sources for on grid Power supply, IJAREEIE, Vol. 2, Issue 11, pp.5466, 2013.
Abstract Views: 450
PDF Views: 1