International Journal of Agricultural Engineering

Open Access Open Access  Restricted Access Subscription Access
Open Access Open Access Open Access  Restricted Access Restricted Access Subscription Access

Design and Performance Evaluation of Portable Folding Type Solar Dryer for Drying of Amla Candy


Affiliations
1 College of Agricultural Engineering and Technology, Dr. Balasaheb Sawant Konkan Krishi Vidyapeeth, Dapoli, Ratnagiri (M.S.), India
     

   Subscribe/Renew Journal


The research was conducted to design and evaluate the performance of portable folding type solar dryer for drying of amla candy. The developed dryer consist of chimney, chimney stand, drying chamber, polyethylene sheet with mosquito net as dome and perforated try. The dryer had capacity of 2 kg per batch of amla candy of thickness 6 to 7 mm. The dimensions of dryer were 0.9 m length, 0.6 m width and 0.6 m height. The collector area was 0.539 m2 with drying cabinet size of 0.9 x 0.6 m. The total cost of construction of dryer was Rs. 1349. Wet amla pieces with and without sugar were selected as drying material. The dryer was tested for its performance at without load and with load. During no load test maximum temperature achieved in dryer was 61.6 °C. The moisture content of 6 mm thick amla pieces treated with sugar was reduced from 281.67 % (db) to 29.93 % (db) in 600 minutes. While moisture content of amla pieces without sugar was reduced from 718.33 % (db) to 58.56 % (db) in 600 minutes. The drying rate of amla pieces with sugar and without sugar had peak value of 1.4126 and 1.6777 g water per gram dry matter per hour, respectively during drying time interval of 8.30 am to 9.30 am of the day. The temperature reached in the dryer was 15 to 20 °C higher than atmospheric temperature.

Keywords

Amla, Amla Candy, Foldable, Portable, Solar Dryer.
Subscription Login to verify subscription
User
Notifications
Font Size


  • Aliyu, B., Kabri, H.U. and Pembi, P.D. (2013). Performance evaluation of a village-level solar dryer for tomato under Savanna Climate: Yola, Northeastern Nigeria. Agric. Engg. CIGR J., 15(1): 181-186.

  • Anand, A. (2012). Development of portable solar dryer for drying of potato chips. Thesis, Dr. B.S. Konkan Krishi Vidyapeeth, Dapoli, Ratnagiri (M.S.) India.

  • Anonymous (2007). Ministry of New and Renewable Energy Solar Energy Centre, MNRE.

  • Bala, B.K. (2005). Solar drying of Jackfruit bulbs and leather using solar tunnel dryer. J. Renewable Energy, 28: 183-190.

  • Basunia, M.A. and Abe, T. (2001). Design and construction of a simple three-shelf solar rough rice dryer. American Medical Association, 32(3): 54-59.

  • Bhattacherjee, A.K. (2013). Quality of aonla candy and segments in syrup prepared from steep preserved fruits in water. Indian J. Natural Products & Resour., 4(1): 119-122.

  • Ekechukwu, L. and Norton, S.D. (1999). Development and use of solar drying technologies. Nigerian J. Solar Energy, 89 : 133-164.

  • Hossain, M.A., Bala, B.K. and Woods, J.L. (2005). Simulation of solar drying of chilli in solar tunnel dryer. Internat. J. Sustainable Energy, 24 : 143-153.

  • Lal, G., Siddhapa, G.S. and Tandon, G.L. (1998). Preservation of fruits and vegetables drying of fruits and vegetables. Indian Council Agric. Res., First Edition, New Delhi: 297-298.

  • Leon, M.A., Kumar, S. and Bhattacharya, S.C. (2002).A comprehensive procedure for performance evaluation of solar food dryers. Renewable & Sustain. Energy Rev., 6: 367-393.

  • Malviya, M.K. and Gupta, R.S. (1985). Design and development of a natural convection solar dryer. J. Agric. Engg., 4: 17-21.

  • Mujaffar, S. and Sankat, C.K. (2004). Sun and solar cabinet drying of salted shark fillets, Proceedings of the 14th International Drying Symposium, Sao Paulo, Brazil: 1584-1591.

  • Mukherjee, R. (1985). Renewable energy for rural development in Arunachal Pradesh. Indian Soc. Agric. Engg., 9(1): 30-35.

  • Pragati, D.S. and Dhawan, S.S. (2003). Effect of drying methods on nutritional composition of dehydrated aonla fruit (Emblica officinalis Garten) during storage. Plant Foods Human Nutri., 58 : 1–9.

  • Prajapati, V.K., Nema, P.K. and Rathore, S.S. (2011). Effect of pretreatment and drying methods on quality of value-added dried aonla (Emblica officinalis Gaertn) shreds. J. Food Sci. & Technolo., 48(1): 45-52.

  • Rai, G.D. (1988). Solar energy utilization. 2nd Ed., Khanna Publishers, New Delhi: 20-92.

  • Sajith, K.G. and Muraleedharan, C. (2013). A study on drying of amla using a hybrid solar dryer. Internat. J. Inn. Res. Sci., Engg. & Technol., 2(1): 794-799.

  • Sengar, S.H., Khandetod, Y.P. and Mohod, A.G. (2009). Low cost solar dryer for fish. African J. Environ. Sci. & Technol., 3(9) : 265-271.

  • Stilling, J., Simon L., Stroeve, P., Thompson, J., Mjawa, B., Kornblutch, K. and Barrett, D.M. (2012). Performance evaluation of an enhanced fruit solar dryer using concentrating panels. Energy Sustain. Development, 16 (2) : 224-230.

  • Sundari, A.R.U., Neelamegam, P. and Subramanian, C.V. (2013). Performance evaluation of forced convection solar dryer with evacuated tube collector for drying amla. Internat. J. Engg. & Technol., 5(3): 56-61.

  • Wankhade, P.K., Sapkal, R.S. and Sapkal, V.S. (2013). Design and performance evaluation of solar dryer. IOSR J. Mechanical & Civil Engg., (ICAET-2014) : 70-73.


Abstract Views: 229

PDF Views: 0




  • Design and Performance Evaluation of Portable Folding Type Solar Dryer for Drying of Amla Candy

Abstract Views: 229  |  PDF Views: 0

Authors

V. D. Paradkar
College of Agricultural Engineering and Technology, Dr. Balasaheb Sawant Konkan Krishi Vidyapeeth, Dapoli, Ratnagiri (M.S.), India
D. J. Shrinivasa
College of Agricultural Engineering and Technology, Dr. Balasaheb Sawant Konkan Krishi Vidyapeeth, Dapoli, Ratnagiri (M.S.), India

Abstract


The research was conducted to design and evaluate the performance of portable folding type solar dryer for drying of amla candy. The developed dryer consist of chimney, chimney stand, drying chamber, polyethylene sheet with mosquito net as dome and perforated try. The dryer had capacity of 2 kg per batch of amla candy of thickness 6 to 7 mm. The dimensions of dryer were 0.9 m length, 0.6 m width and 0.6 m height. The collector area was 0.539 m2 with drying cabinet size of 0.9 x 0.6 m. The total cost of construction of dryer was Rs. 1349. Wet amla pieces with and without sugar were selected as drying material. The dryer was tested for its performance at without load and with load. During no load test maximum temperature achieved in dryer was 61.6 °C. The moisture content of 6 mm thick amla pieces treated with sugar was reduced from 281.67 % (db) to 29.93 % (db) in 600 minutes. While moisture content of amla pieces without sugar was reduced from 718.33 % (db) to 58.56 % (db) in 600 minutes. The drying rate of amla pieces with sugar and without sugar had peak value of 1.4126 and 1.6777 g water per gram dry matter per hour, respectively during drying time interval of 8.30 am to 9.30 am of the day. The temperature reached in the dryer was 15 to 20 °C higher than atmospheric temperature.

Keywords


Amla, Amla Candy, Foldable, Portable, Solar Dryer.

References