Research Journal of Topical and Cosmetic Sciences

Open Access Open Access  Restricted Access Subscription Access
Open Access Open Access Open Access  Restricted Access Restricted Access Subscription Access

Nanoemulsion: Current State and perspectives


Affiliations
1 Department of Oils, Oleochemicals & Surfactants Technology, Institute of Chemical Technology, Matunga, Mumbai-400019, India
     

   Subscribe/Renew Journal


Nano-emulsions are obtained when the size of an emulsion globule reaches approximately 20-500 nm. The small droplet size can resist the physical destabilization caused by gravitational separation, flocculation and coalescence. It also avoids the creaming process because the droplet's Brownian motion is enough to overcome the gravitational separation force present characteristics and properties which depend on composition and the preparation method. Although interest in nano-emulsions was developed since about 20 years ago, mainly for nanoparticle preparation, it is in the last years that direct applications of nano-emulsions in consumer products are being developed, mainly in pharmacy and cosmetics. Nanoemulsion show great promise for the future of cosmetics, diagnostics, drug therapies and biotechnologies, emulsion fuel. The formation, properties and applications of nano-emulsions (also referred to as miniemulsions, ultrafine emulsions, and submicron emulsions) are reviewed and summarized. Nano-emulsion droplet sizes fall typically in the range of 20–200 nm and show narrow size distributions. Although most of the publications on either oil-in-water (O/W) or water-in-oil (W/O) nano-emulsions report their formation by dispersion or high-energy emulsification methods, an increased interest is observed in the study of nano-emulsion formation by condensation or low-energy emulsification methods (based on the phase transitions that take place during the emulsification process). Aim of this review is focus on nanoemulsion advantage and disadvantage, various methods of preparation, characterization techniques and the various new applications of sub micron size emulsion in different areas.

Keywords

Nanoemulsion, Cosmetics, Diagnostics, Drug Therapies, Biotechnologies, Emulsion Fuel.
Subscription Login to verify subscription
User
Notifications
Font Size


  • Tadros t., izquierdo p., esquena j., solans c., formation and stability of nanoemulsions, Colloid Interface Sci., 108, 2004, pp. 303-318.

  • Sadtler V., Rondon-Gonzalez M, Acrement A., Choplin A., Marie E., Peo-covered nanoparticles by emulsion inversion point (eip) method, Macromol. Rapid Commun., 31, 2010, pp. 998- 1002.

  • M.S. El-Aasser, E.d. Sudol, Miniemulsions: Overview of research and applications, jct. Res. 1 (1) (2004) 21–31.

  • H. Nakajima, Microemulsions in cosmetics, in: C. Solans, H. Kunieda (Eds.), Industrial Applications of microemulsions, Marcel Dekker, New York, 1997, pp. 175– 197.

  • O. Sonneville-Aubrun, J.T. Simonnet, F. L’alloret, nanoemulsions a new vehicle for skincare products, adv. Colloid Interface Sci. 108– 109 (2004) 145–149.

  • S. Amselem, D. Friedman, Submicron emulsions as drug carriers for topical administration, in: s. Benita (ed.), submicron emulsions in drug targeting and delivery, Harwood Academic Publishers, London, 1998, pp. 153– 173.

  • O. Sonneville-Aubrun, J.-T. Simonnet, F. L’alloret, Nanoemulsions: a new vehicle for skincare products advances in Colloid and Interface Science 108 –109 (2004) 145–149.

  • P. Walstra, Emulsion stability, in: P. Becher (ed.), Encyclopedia of Emulsion Technology, Marcel Dekker, New York, 1996, pp. 1–62.

  • J. Floury, A. Desrumaux, M.A.V. Axelos, J. Legrand, Effect of high pressure homogenisation on methycellulose as food emulsifier, J. Food. Eng. 58 (2003) 227– 238.

  • K. Landfester, J. Eisenbla¨tter, R. Rothe, Preparation of polymerizable miniemulsions by ultrasonication, Jct Res. 1 (2004) 65– 68.

  • K. Shinoda, H. Saito, The effect of temperature on the phase equilibria and the types of dispersion of the ternary system composed of water, cyclohexane, and nonionic surfactant, J. Colloid Interface Sci. 26 (1968) 70– 74.

  • M.J. Rang, C.A. Miller, Spontaneous emulsification of oils containing hydrocarbon, nonionic surfactant, and oleyl alcohol, J. Colloid Interface Sci. 209 (1999) 179– 192.

  • T. Forster, W.V. Rybinski, applications of emulsions, in: B.P. Binks (ed.), Modern aspects of emulsion science, the royal society of chemistry, Cambridge, 1998, pp. 395–426.

  • Ahuja A Ali J, Baboota S, Faisal M.S, Shakeell F and Shafiq S: Stability evaluation of celecoxib nanoemulsion containing tween 80. Thai J. Pharm. Sci. 2008;32 :4-9.

  • Ali Javed Ahuja Alka, Baboota S, Shakeel F, Shafiq S: Design development and evaluation of novel nanoemulsion formulations for transdermal potential of celecoxib. Acta Pharm.2007; 57 315–33210.2478/v10007-007-0025-5.

  • Solans C, Esquena J, Forgiarini AM, Usón N, Morales D, Izquierdo P, Azemar N, Garcia-Celma MJ. Nano-emulsions: formation, properties and applications. Surfactant science series 2003; 109:525–54. First review on nano-emulsions obtained by low energy methods.

  • International union of pure and applied chemistry; Manual of Colloid Science. London: Butterworth; 1972.

  • Hélder Daniel Silva, Miguel Ângelo Cerqueira , António A. Vicente, Nanoemulsions for Food Applications: Development and Characterization Food Bioprocess Technol (2012) 5:854–867

  • K Shinoda, H Kunieda. J Colloid Interface Sci 42:381, 1973.

  • K Shinoda, H Kunieda. In: P Becher, ed. Encyclopedia of emulsion technology. Vol. 1. New York: Marcel Dekker, 1983, pp 337-367.

  • S. Benita, M. Y. Levy,J. Pharm. Sci.,1993, 82, 1069.

  • Tharwat F. Tadros Applied surfactants: principles and applications. ISBN: 3-527-30629-3 page 285-86.

  • Chen Huabing , Du Danrong , Mao Chengwen Mou Dongsheng, Wan Jiangling, Xu Huibi, Yang Xiangliang: Hydrogel-thickened nanoemulsion system for topical delivery of lipophilic drugs. International Journal of Pharmaceutics 2008; 353:272.

  • Pavankumar VK, Nanoemulasions, Pharmainfo.net; 2008.

  • Thompson.W ,Kelin L, On the equilibrium of vapour at curved surface of liquid,1871 Phil.Marg,42-448

  • SL Hari Kumar, Vishal Singh , Nanoemulsification - a novel targeted drug delivery tool, Journal of Drug Delivery & therapeutics; 2012, 2(4), 40-45.

  • Wang, L., R. Tabor, J. Eastoe, X. Li, K. Richard, et al., 2004. Formation and stability of nonoemulsion with mixed ionicnonionic surfactants. Colloid and Interface Science, 108: 303- 318.

  • Bhatt, P. and S. Madhav,. A detailed. Review on nanoemulsion drug delivery system. International Journal Pharmacy Science and Research,2011 2(9): 2292-2298.

  • Kamat, P.V., S.K. Pansare, S.R. Parakh, S.C. Jagdale, R.A. Patil, et al.. Pharmaceutical nanotechnology novel nanoemulsion-high energy concept of emulsification preparation, application. The Pharma Research, 2010,3: 117-138.

  • R.B. Desi Reddy, Ch.T. Lalitha Kumari, G. Naga Sowjanya, S.L. Sindhuri, P. Bandhavi, Nanoemulsions an emerging trend: A review ,IJPRD, 2011; Vol 4(06): August-2012 (137 – 152).

  • Bourne Dwa and Dittert LW. Chapter 3 in modern pharmaceutics 3rd ed., Banker GS and Rhodes.CT. Ed. Dekker. New York, 1996.

  • R. Rajalakshmi, K. Mahesh, C.K. Ashok Kumar , A critical review on nano emulsions, International Journal of Innovative Drug Discovery/ vol 1/ issue 1/ 2011/ 1-8.

  • S.C. kothekar, J.T. Waghmare, S.A. Momin, Rationalizing and producing nanoemulsion for personal care, Cosmetics & Toiletries July 2006 vol.121no.7

  • Gh Lowell, RW Kaminski, TC Vancott, B Silkie, K Kersey, E Zawoznik, L Loomis-Price, G Smith, DL Birx. J Infect Dis 175:292-301, 1997.

  • P Calvo, MJ Alonso, J Vila-Jato. J Pharm Sci 85:530-536, 1996.

  • MP Youenang Piemi, D Komer, S Benita, JP Marty. J Controlled Release 58(2):177-187, 1999

  • JS Schwartz, MR Weisspapir, DI Friedman. Pharm Res 12:687- 692, 1995.

  • DI Friedman, JS Schwarz, MR Weisspapir. J Pharm Sci 84:324- 329, 1995

  • Sharma, N., M. Bansal and S. Visht, 2010 Nanoemulsion: a new Concept of Delivery System, 1(2): 2-6.

  • Patel, P.D., G.J. Patel, P.D. Bharadia, V.M. Pandya and D.A. Modi, 2011. Nanoemulsion: an advance concept of dosage form. Journal and Cosmetology, 5(1): 122-133.

  • J Ugelstad, MS El-Aasser, JW Vanderhoff. J Polym Sci Polym Lett 11:503, 1973.

  • (a) FJ Schork, GW Poehlein, S Wang, J Reimers, J Rodrigues, C Samer. Colloids Surf a 153:39-45, 1999. (b) DT Barnette, FJ Schork. Chem Eng Prog 83:25, 1987.

  • Charles Lovelyn, Anthony A. Attama, Current State of nanoemulsions in Drug Delivery, Journal of Biomaterials and Nanobiotechnology, 2011, 2, 626-639.


Abstract Views: 1661

PDF Views: 0




  • Nanoemulsion: Current State and perspectives

Abstract Views: 1661  |  PDF Views: 0

Authors

Harshal Patil
Department of Oils, Oleochemicals & Surfactants Technology, Institute of Chemical Technology, Matunga, Mumbai-400019, India
Jyotsna Waghmare
Department of Oils, Oleochemicals & Surfactants Technology, Institute of Chemical Technology, Matunga, Mumbai-400019, India

Abstract


Nano-emulsions are obtained when the size of an emulsion globule reaches approximately 20-500 nm. The small droplet size can resist the physical destabilization caused by gravitational separation, flocculation and coalescence. It also avoids the creaming process because the droplet's Brownian motion is enough to overcome the gravitational separation force present characteristics and properties which depend on composition and the preparation method. Although interest in nano-emulsions was developed since about 20 years ago, mainly for nanoparticle preparation, it is in the last years that direct applications of nano-emulsions in consumer products are being developed, mainly in pharmacy and cosmetics. Nanoemulsion show great promise for the future of cosmetics, diagnostics, drug therapies and biotechnologies, emulsion fuel. The formation, properties and applications of nano-emulsions (also referred to as miniemulsions, ultrafine emulsions, and submicron emulsions) are reviewed and summarized. Nano-emulsion droplet sizes fall typically in the range of 20–200 nm and show narrow size distributions. Although most of the publications on either oil-in-water (O/W) or water-in-oil (W/O) nano-emulsions report their formation by dispersion or high-energy emulsification methods, an increased interest is observed in the study of nano-emulsion formation by condensation or low-energy emulsification methods (based on the phase transitions that take place during the emulsification process). Aim of this review is focus on nanoemulsion advantage and disadvantage, various methods of preparation, characterization techniques and the various new applications of sub micron size emulsion in different areas.

Keywords


Nanoemulsion, Cosmetics, Diagnostics, Drug Therapies, Biotechnologies, Emulsion Fuel.

References