The Indian Journal of Nutrition and Dietetics

Open Access Open Access  Restricted Access Subscription Access
Open Access Open Access Open Access  Restricted Access Restricted Access Subscription Access

Influence of Emulsifiers and Heat Moisture Treatment of Millets on Quality of Gluten-Free Chhana Cake


Affiliations
1 Dairy Technology Department, SMC College of Dairy Science, Kamdhenu University, Anand - 388 110, India
     

   Subscribe/Renew Journal


The present investigation was conducted to develop a technology for the manufacture of a gluten-free chhana cake. Refined wheat flour was substituted with blend of three flours viz., barnyard millet, amaranth and little millet (consisting of 31.86% barnyard millet, 32.69% amaranth and 35.45% little millet) were subjected to heat moisture treatment. In order to select the most suitable heat moisture treatment the millet blend was subjected to three heat moisture treatments. Based on the results the selected heat moisture treatment was: Adjusting the moisture content of millet flour blend to 25% and keeping it at 4°C for 24 h in an air tight plastic container followed by heating the moisture adjusted flour at 100°C for 3 h in a hot air oven and finally drying it at 40°C till a final moisture content of about 9% was obtained. In the second part of the study, the rate of addition of baking powder and glycerol monostearate was optimized using Response Surface Method (RSM) i.e., Design Expert 13.0.5.0. The optimized solution was 1.40% baking powder and 1.66% glycerol monostearate. The desirability of this model was 0.93.


Keywords

Gluten-Free, Millet, Bakery Products, Celiac Disease, Moisture, Emulsifier.
User
Notifications

  • Puranik, D.B. and Gupta, S.K. Development of egg-less cake using whey protein concentrate as egg substitute. Int. J. Sci. Environ. Technol., 2017, 6, 2343-2352.

  • Chappalwar, V.M., Peter, D., Bobde, H. and John, S.M. Quality characteristics of cookies prepared from oats and finger millet based composite flour. Engin. Sci. Technol. Int. J., 2013, 3, 677-683.

  • Rao, D.B., Ananthan, R., Hariprasanna, K., Bhatt, V., Rajeswari, K., Sharma, S. and Tonapi, V.A. Nutritional and health benefits of nutri cereals. ICAR-Indian Institute of Millets Research (IIMR), Hyderabad, India, 2018.

  • Hosseini, S.M., Soltanizadeh, N., Mirmoghtadaee, P., Banavand, P., Mirmoghtadaie, L. and Shojaee-Aliabadi, S. Gluten-free products in celiac disease: Nutritional and technological challenges and solutions. J. Res. Med. Sci., 2018, 23, 109-126.

  • Silano, M., Volta, U., Mecchia, A.M., Dessì, M., Di Benedetto, R. and De Vincenzi, M. Delayed diagnosis of coeliac disease increases cancer risk. BMC Gastroenterol., 2007, 7, 1-5.

  • Sategna-Guidetti, C., Volta, U., Ciacci, C., Usai, P., Carlino, A., De Franceschi, L. and Brossa, C. Prevalence of thyroid disorders in untreated adult celiac disease patients and effect of gluten withdrawal: an Italian multicenter study. The Am. J. Gastroenterol., 2001, 96, 751-757.

  • Glimberg, I., Haggård, L., Lebwohl, B., Green, P.H. and Ludvigsson, J.F. The prevalence of celiac disease in women with infertility- A systematic review with meta-analysis. Reprod. Med. Biol., 2021, 20, 224-233.

  • Ludvigsson, J., Montgomery, S. and Ekbom, A. Celiac disease and risk of adverse fetal outcome a population-based cohort study: G1-03. J. Pediat. Gastroenterol. Nutr., 2005, 40, 625.

  • Feighery, C. Celiac disease. Br. Med. J., 1999, 319, 236-239.

  • Hill, I.D., Dirks, M.H., Liptak, G.S., Colletti, R.B., Fasano, A., Guandalini, S. and Seidman, E.G. Guideline for the diagnosis and treatment of celiac disease in children: recommendations of the North American Society for Pediatric Gastroenterology, Hepatology and Nutrition. J. Pediat. Gastroenterol. Nutr., 2005, 40, 1-19.

  • Makharia, G.K., Verma, A.K., Amarchand, R., Bhatnagar, S., Das, P., Goswami, A. and Anand, K. Prevalence of celiac disease in the northern part of India: A community based study. J. Gastroenterol. Hepatol., 2011, 26, 894-900.

  • Rai, S., Kaur, A. and Singh, B. Quality characteristics of gluten free cookies prepared from different flour combinations. J. Fd. Sci. Technol., 2014, 51, 785-789. https://doi.org/10.1007/s13197-011-0547-1

  • Lagrain, B., Brijs, K., Veraverbeke, W.S. and Delcour, J.A. The impact of heating and cooling on the physico-chemical properties of wheat gluten–water suspensions. J. Cereal Sci., 2005, 42, 327-333.

  • Houben, A., Hochstotter, A. and Becker, T. Possibilities to increase the quality in gluten-free bread production: an overview. Eur. Fd. Res. Technol., 2012, 235, 195-208.

  • Arendt, E.K., Morrissey, A., Moore, M.M. and Dal Bello, F. Gluten-free breads. In E. Arendt and F. Dal Bello (Eds.), Gluten-free cereal products and beverages. Academic Press: United Kingdom, 2008, pp. 289-296.

  • Chung, H.J., Liu, Q. and Hoover, R. Impact of annealing and heat-moisture treatment on rapidly digestible, slowly digestible and resistant starch levels in native and gelatinized corn, pea and lentil starches. Carbohydrate Polymers, 2009, 75, 436-447.

  • Maache-Rezzoug, Z., Zarguili, I., Loisel, C., Queveau, D. and Buleon, A. Structural modifications and thermal transitions of standard maize starch after DIC hydrothermal treatment. Carbohydrate Polymers, 2008, 74, 802-812.

  • Jacobs, H. and Delcour, J.A. Hydrothermal modifications of granular starch, with retention of the granular structure: A review. J. Agricult. Fd. Chem., 1998, 46, 2895-2905.

  • Arns, B., Paraginski, R.T., Bartz, J., de Almeida Schiavon, R., Elias, M. C., da Rosa Zavareze, E. and Dias, A. R. G. The effects of heat–moisture treatment of rice grains before parboiling on viscosity profile and physicochemical properties. Int. J. Fd. Sci. Technol., 2014, 49, 1939-1945.

  • Miyazaki, M., Van Hung, P., Maeda, T. and Morita, N. Recent advances in application of modified starches for bread making. Trds. Fd. Sci. Technol., 2006, 17, 591-599.

  • De Leyn, I. Other functional additives. In Y.H. Hui, H. Corke, I. De Leyn, W.K. Nip and N.A. Cross (Eds.), Bakery products science and technology. Wiley Blackwell: Chichester, United Kingdom, 2014, pp. 295-306.

  • Cauvain, S.P. Cakes: nature of cakes. In L.C. Trugo and P. M. finglas (Eds.), Encyclopedia of Food Sciences and Nutrition. Academic Press: London, United Kingdom, 2003, pp. 751–756.

  • Manley, D. In: Technology of biscuits, crackers and cookies. CRC Press: Washington DC, New York, 2000.

  • Arozarena, I., Bertholo, H., Empis, J., Bunger, A. and Sousa, I. Study of the total replacement of egg by white lupine protein, emulsifiers and xanthan gum in yellow cakes. Eur. Fd. Res. Technol., 2001, 213, 312-316.

  • Turabi, E., Sumnu, G. and Sahin, S. Rheological properties and quality of rice cakes formulated with different gums and an emulsifier blend. Fd. Hydrocoll., 2008, 22, 305-312.

  • Ertop, M.H. and Hayta, M. Optimization of the level of chickpea sourdough and baking powder in cake formulation by response surface methodology: Effects on physicochemical, sensory and antioxidant properties. Fd. Sci. Technol. Res., 2018, 24, 697-706.

  • Veluppillai, S., Nithyanantharajah, K., Vasantharuba, S., Balakumar, S. and Arasaratnam, V. Optimization of bread preparation from wheat flour and malted rice flour. Rice Sci., 2010, 17, 51-59.

  • Salama, A., Soad, E., Abul-Fadl, M.M., Bedeir, S.H. and Aliaa, E. The influence of xanthan gum or glycerol mono stearate incorporation on the quality characteristics of sponge cake. J. Appl. Sci. Res., 2013, 9, 5390-5402.

  • Sarabhai, S., Indrani, D., Vijaykrishnaraj, M., Arun Kumar, V. and Prabhasankar, P. Effect of protein concentrates, emulsifiers on textural and sensory characteristics of gluten free cookies and its immunochemical validation. J. Fd. Sci. Technol., 2015, 52, 3763-3772.


Abstract Views: 610

PDF Views: 0




  • Influence of Emulsifiers and Heat Moisture Treatment of Millets on Quality of Gluten-Free Chhana Cake

Abstract Views: 610  |  PDF Views: 0

Authors

Hitesh Jambukiya
Dairy Technology Department, SMC College of Dairy Science, Kamdhenu University, Anand - 388 110, India
Suneeta Pinto
Dairy Technology Department, SMC College of Dairy Science, Kamdhenu University, Anand - 388 110, India
Sunil Patel
Dairy Technology Department, SMC College of Dairy Science, Kamdhenu University, Anand - 388 110, India

Abstract


The present investigation was conducted to develop a technology for the manufacture of a gluten-free chhana cake. Refined wheat flour was substituted with blend of three flours viz., barnyard millet, amaranth and little millet (consisting of 31.86% barnyard millet, 32.69% amaranth and 35.45% little millet) were subjected to heat moisture treatment. In order to select the most suitable heat moisture treatment the millet blend was subjected to three heat moisture treatments. Based on the results the selected heat moisture treatment was: Adjusting the moisture content of millet flour blend to 25% and keeping it at 4°C for 24 h in an air tight plastic container followed by heating the moisture adjusted flour at 100°C for 3 h in a hot air oven and finally drying it at 40°C till a final moisture content of about 9% was obtained. In the second part of the study, the rate of addition of baking powder and glycerol monostearate was optimized using Response Surface Method (RSM) i.e., Design Expert 13.0.5.0. The optimized solution was 1.40% baking powder and 1.66% glycerol monostearate. The desirability of this model was 0.93.


Keywords


Gluten-Free, Millet, Bakery Products, Celiac Disease, Moisture, Emulsifier.

References